info@polydome.ie
057 912 0424
Polydome Ltd, Birr, County Offaly, R42 VX36
View Map
info@polydome.ie
057 912 0424
Polydome Ltd, Birr, County Offaly, R42 VX36 Polytunnel 6m x 20m
Our 6m wide Polytunnel has extra height and high sides so gives a really good feeling of space inside. It is extremely robust with long foundation tubes that sleeve inside the straight legs of the hoops to strengthen them and the steel is larger diameter than our smaller Polytunnels. It is basically similar strength to our commercial models. The shelter it provides protects plants from the ravages of the weather and promotes rapid and healthy growth.
Please note when sizing a plot of ground for a Polytunnel we recommend you add at least 3m to the width of the Polytunnel and 4m to the length. See more detail in the Siting and Preparation section.
When sizing a Polytunnel for a plot of ground we would recommend you add at least 4m to the width of the Polytunnel and 4m to the length. This is for room to dig trenches, avoid snagging your cover on obstacles, good ventilation, allowing run off water to drain away, room for unrolling the polythene at the gables during covering etc.
If you really need to economise on space, opting for Sliding Doors (rather than hinging doors) and an aluminium cladding rail will reduce the space needed too – but ventilation will be restricted if you don’t have much room at your gables (between the Polytunnel and walls or tall plants etc.).
Avoid siting below trees as the run-off water from them will make the tunnel very dirty regularly and the tunnel may well be damaged from time to time by debris falling from the tree in storms.
The best orientation for strength is to face your gable end towards the prevailing wind, if you have a slope on the site run the length of the tunnel down the slope. With these Polytunnels the ground must not have more than a 10cm slope across the width of the tunnel – unless you order a custom model designed to accommodate the slope (but generally it is a good idea not to have a slope across the width as you will have gaps below doors and other issues, so its better to level the ground instead).
If installing the Polytunnel on soil – the foundation tubes normally go into the ground to a depth of 60cm. Make sure if you have any pipes or cables crossing the site to mark their exact position and know the exact depth of them so that when building your Polytunnel they are not damaged.
- Straight Sided – more useable space inside.
- High Strength Design – an investment in quality is never regretted.
- Cover tensioning system – your polythene cover can be easily tensioned in warm weather prolonging its life.
- Configurable Design – Design your Polytunnel to suit your requirements.
- Simple construction – any handy DIY person should have no problem to install it.
- Good back up support for DIY – tech support over the phone, videos, instructions.
- Greenhouse effect – enables growers to grow exotic varieties, improves plant quality and growth.
- Can be configured for multiple uses (sheep farmers, Garden Centre Canopies etc.)
Our steel tube is primarily ‘Magna Coated’ (or similar) which as well as zinc has aluminium and magnesium to provide up to 20 times more corrosion resistance than ordinary pre-galv steel tube.
Hoops:
50.8mm diameter x 1.5mm wall thickness high tensile hoops at 2m centres.
Ridge bars, roof end braces and corner brace bars:
50.8mm diameter x 1.5mm wall thickness high tensile steel.
There are eight brace bars.
Foundation tubes:
44.5mm diameter x 2mm wall thickness (1350mm long).
Our foundation tubes sleeve inside the straight leg of each hoop to reinforce it (where it is under most stress in wind).
Height
Please note the ridge height shown assumes the bottom of the hoop would be at ground level. Typically the hoop is lifted off the ground by around 18cm to allow for fitting of aluminium cladding rails to the foundation tubes, increasing the height by 180mm.
Features and Benefits
Straight Sided
High Strength Design
Configurable Design
Simple construction
Good back up support for DIY
Greenhouse effect
